Maytag Dishwasher Manual de Serviço

MMaayyttaagg TTaallll TTuubb DDiisshhwwaasshheerr

Slide 18 Slide 19

Slide 20 – Section Three: Dispenser Assembly Slide 21

Slide 22

Slide 23 Slide 24 – Section Four: Water Valve, Turbidity Sensor, Heating Element, Motor Capacitor and Limit Thermostat

Slide 25

Slide 26 Slide 27

Slide 28

Slide 29 Slide 30

Slide 31 Slide 32

Slide 33 Slide 34

Notes:

Slide 35 – Section Five: Water Flow and Filtering Slide 36 Slide 37

Slide 38 - Section Six: Pump Assembly Removal and Service Slide 39 Slide 40

Slide 41 Slide 42

Slide 43 Slide 44

Slide 45

Slide 46

Slide 47 Slide 48 – Section Seven: Cycles and Options

Slide 49

Slide 50 Slide 51 – Section Eight: Troubleshooting

Slide 52

Slide 1 Slide 2 – Section One: General Information Slide 3

Slide 53

Slide 54

Jet Clean IIStainless SteelDishwashersThis Base Manual covers general informationRefer to individual Technical Sheetfor information on specific models

2 16022783 Rev. 0 ©2004 Maytag Appliances CompanyImportant Notices for Servicers and ConsumersMaytag will not be responsible for personal injury or p

©2004 Maytag Appliances Company 16022783 Rev. 0 3Table of ContentsWill Not Wash ... 18Will Not Drai

4 16022783 Rev. 0 ©2004 Maytag Appliances Company Important Safety InformationWARNING!To avoid personal injury or death from improperservicing, make

©2004 Maytag Appliances Company 16022783 Rev. 0 5Important Safety InformationPRECAUCIÓN: Desconecte laenergía eléctricaantes de darieservicio.ATENCI

6 16022783 Rev. 0 ©2004 Maytag Appliances Company WARNING: Disconnect power before servicing. Electronic control is eergized at all times until

©2004 Maytag Appliances Company 16022783 Rev. 0 7Electrical Equipment & TestingElectrical Test EquipmentThe equipment required to service these

8 16022783 Rev. 0 ©2004 Maytag Appliances CompanyVOLTAGE CHECKSGenerally, these checks will consist of taking readingsat the wall receptacle in order

Slide 4 Slide 5

©2004 Maytag Appliances Company 16022783 Rev. 0 9for protection against shock hazard and should beplugged directly into a properly grounded and pola

10 16022783 Rev. 0 ©2004 Maytag Appliances CompanyCycles & OptionsCycle DescriptionAuto Clean Designed to auto select the number of fills and len

©2004 Maytag Appliances Company 16022783 Rev. 0 11Option DescriptionTough Scrub™ This option adds fills, heat and/or wash time to theTough Scrub Plu

12 16022783 Rev. 0 ©2004 Maytag Appliances CompanyDisplay DescriptionClean The "Clean" light illuminates at the end of the cycle and remain

©2004 Maytag Appliances Company 16022783 Rev. 0 13MDB8750HeavyWashNormalWashLightWashRinseOnlyAutoCleanSTART/CancelDELAY1-9SanitizeToughExtraRinseHe

©2004 Maytag Appliances Company 16022783 Rev. 0 14 Electrical-Mechanical TroubleshootingWill Not FillWater Access ValveCheck to determine if the val

15 16022783 Rev. 0 ©2004 Maytag Appliances CompanyFiltersCheck for blockage of Strainer, Over Pressure Filter.Repair as necessary.Poor WashabilitySpr

©2004 Maytag Appliances Company 16022783 Rev. 0 16ThermostatCheck mating surface of the High Limit Thermostat faceto surface of tub enclosure. Cont

17 16022783 Rev. 0 ©2004 Maytag Appliances CompanyWill Not WashWash MotorCheck Wash Motor circuit. See data listed on theTechnical Sheet, located beh

Troubleshooting Flow Chart ©2004 Maytag Appliances Company 16022783 Rev. 0 18Is the power turnedon to the unit at thebreaker panel orfuse box?Verify w

Slide 6 Slide 7

Troubleshooting Flow Chart 16022783 Rev. 0 ©2004 Maytag Appliances Company 19Is there a leak at thetop of the door?Does it leak whenyou open the do

Troubleshooting Flow Chart ©2004 Maytag Appliances Company 16022783 Rev. 0 20BIs the incomingwater under the sinkleaking?Is the drain hosegoing into t

Troubleshooting Flow Chart 16022783 Rev. 0 ©2004 Maytag Appliances Company 21Cycle SelectionProblem

Troubleshooting Flow Chart ©2004 Maytag Appliances Company 16022783 Rev. 0 22Is there a problemwith the door or doorlatch?NoWill the door clo seand la

Troubleshooting Flow Chart 16022783 Rev. 0 ©2004 Maytag Appliances Company 23Can the wash armsrotate freely?Is the washperformance good?YesNoNoYesA

Troubleshooting Flow Chart ©2004 Maytag Appliances Company 16022783 Rev. 0 24Are any of the spraynozzles clogged?Is the redepeverywhere?Are items nest

Troubleshooting Flow Chart 16022783 Rev. 0 ©2004 Maytag Appliances Company 25Was the "HeatedDry" optionselected?Instruct touse "Heat

Troubleshooting Flow Chart ©2004 Maytag Appliances Company 16022783 Rev. 0 26Has the operation ofthe vent wax motorbeen verified?Run FieldService test

Troubleshooting Flow Chart 16022783 Rev. 0 ©2004 Maytag Appliances Company 27Does the noise onlyoccur during the fillportion of the cycle?Does it s

Troubleshooting Flow Chart ©2004 Maytag Appliances Company 16022783 Rev. 0 28AIs the water valvetouching the tub?Adjustwater valveIs the drain hosewed

Slide 8 - Adjustments Slide 9 Slide 10

29 16022783 Rev. 0 ©2004 Maytag Appliances CompanyService and Disassembly Procedures! WARNINGTo avoid risk of electrical shock, personal injury, or d

©2004 Maytag Appliances Company 16022783 Rev. 0 30Inner Door PanelRemoval of the Inner Door Panel will allow access to theMicroprocessor Board, Door

31 16022783 Rev. 0 ©2004 Maytag Appliances CompanyWax Motor Detergent / Rinse DispenserRemoval1. Disconnect power to the machine.2. Remove the Inner

©2004 Maytag Appliances Company 16022783 Rev. 0 32Door Latch & Switch Holder AssemblyTwo Door Switches are used in the Latch Assembly. Bothswit

33 16022783 Rev. 0 ©2004 Maytag Appliances CompanyPC BoardRemoval1. Disconnect power to the machine.2. Remove the Inner Door Panel. (See paragraph In

©2004 Maytag Appliances Company 16022783 Rev. 0 34Removal1. Disconnect power to the machine.2. Remove Torx™ screw securing Strike to Tub.DOOR GASKET

35 16022783 Rev. 0 ©2004 Maytag Appliances CompanyDoor Hinge and SupportRemoval1. Disconnect power to the machine.2. Remove the Outer Door Panel. (Se

©2004 Maytag Appliances Company 16022783 Rev. 0 36Over Pressure FilterThe purpose of the Over Pressure Filter is to filtersediment missed by the low

37 16022783 Rev. 0 ©2004 Maytag Appliances CompanyManifoldWater is supplied to the Top and Center Wash Armsthrough this tube via the Pump Assembly. T

©2004 Maytag Appliances Company 16022783 Rev. 0 38FloatThe Float Assembly controls the amount of water fill.The Float Switch is wired in series with

Slide 11 Slide 12

39 16022783 Rev. 0 ©2004 Maytag Appliances CompanyHeating ElementThe purpose of the Heating Element is to provide heatduring the dry cycle and increa

©2004 Maytag Appliances Company 16022783 Rev. 0 40ThermostatsTwo types of thermostats are used in the Dishwasher. AThermistor and a Limit Thermosta

41 16022783 Rev. 0 ©2004 Maytag Appliances CompanyChecking Valve OperationNo Fill1. Disconnect power to the machine.2. Remove Support and Toe Panel.

©2004 Maytag Appliances Company 16022783 Rev. 0 42Replacement1. Examine the Air Water Inlet Seal for damage.2. Align Air Water Inlet tabs with notch

43 16022783 Rev. 0 ©2004 Maytag Appliances CompanyDrain PumpThe Drain Pump will drain water from the Dishwasher invarious cycles. If a failure is sus

©2004 Maytag Appliances Company 16022783 Rev. 0 44Service and Disassembly Procedures! WARNINGTo avoid risk of electrical shock, personal injury, or

©2004 Maytag Appliances Company 16022783 Rev. 0 A - 1Appendix A

Printed in USA ©2003 Maytag Corporation 6 918789Rev ABuilt-In DishwasherLavavajillas Empotrado/Lave-vaisselle encastréInstallation Instructions/Instr

Built-In DishwasherInstallation InstructionsLeave Installation Instructions and User’s Guide with OwnerALL ELECTRICAL WIRING, GROUNDING AND PLUMBING S

Slide 13 Slide 14

Lavavajillas EmpotradoInstrucciones de InstalaciónDeje las instrucciones de instalación y la guía del usuario con el propietario.TODO EL CABLEADO ELÉC

Lave-vaisselle encastréInstructions d’installationLaisser les instructions d’installation et le mode d’emploi aupropriétaireTOUT LE CÂBLAGE ÉLECTRIQUE

2ASelect models onlyCiertos modelos solamenteModèles sélectionnés seulement12 Mounting Strips(installed on unit)2 Cintas de Montaje(instaladas en la u

79523""7⁄8 to 243⁄864H331/2"335/8"333/4"X1/4"3/8"1/2"::::H337/8"34"341/8"X5/8"3/4"7/8

14Never push with kneeNunca lo empuje con la rodillaNe pas pousser avec le genouIMPORTANT /IMPORTANTE 13B13A1113A141315IMPORTANT/IMPORTANTEPanel damag

2317OFF / APAGADO /ARRÊT183 1194220GROUND/ PUESTA A TIERRA/ MISE À LA TERRE2221WHITE TO WHITE (NEUTRAL) BLANCO CON BLANCO (NEUTRO) FIL BLANC À BORNE B

28291/8IMPORTANT/IMPORTANTE263/16"3/16"27Level left to rightNivele de izquierda a derechaNiveau de gauche à droiteLevel left to rightNivele

33353637341234Turn on water, power and machine / Abra la llave de agua, conecte la corriente y encien-da el aparato / Ouvrir le robinet d’eau, l’alime

zzz39ASelect models onlyCiertos modelos solamenteModèles sélectionnés seulementz40ASelect models onlyCiertos modelos solamenteModèles sélectionnés seu

Notes:

Slide 15 – Section Two: Gasket and Door Service Slide 16 Slide 17